Tractor Safety and Operation Basics
A Tractor Operator:
- Must be at least 18 years old and have a current driver’s license.
- Be trained on the specific tractor and implements they will be using prior to operating equipment.
A Tractor Operator Is Responsible for the Following:
- Using the right tractor and implement for the job.
- Conducting tractor pre-operation checks.
- Knowing equipment blind spots.
- Previewing the route for obstacles, holes, slopes, ditches, terrain, etc. Removing debris in the tractor’s pathway.
- Operating the tractor and implements safely in accordance to the manufacturer’s directions.
- Continual awareness of potential hazards.
Tractor Operator Training Should Include:
- Tractor hazards, operational basics, and familiarity with operator manuals and their location.
- Importance of not operating equipment with mechanical problems, missing shields, or other safety devices.
- Familiarity of hazardous terrains where the tractor will be used.
- Passing a competency test drive for tractor and implement operation.
- Written training documentation.
Common Tractor Accidents:
- Rearward Roll Over occurs when: the tractor is stuck in mud or snow preventing the rear wheels from rotating; the rear wheels cannot turn because the incline is too steep; the clutch is released too quickly with the transmission in a lower gear and the engine at a high speed; or the load is too heavy and/or hitched above the tractor’s drawbar.
- Sideways Roll Over occurs when: the tractor is driven on a hillside that is too steep or too close to the edge of a roadside ditch or embankment; cornering too sharply or too fast; or the tractor’s front-end loader is elevated too high on a hillside or in a turn at excessive speeds.
- Front-End Loader Incidents occur when: lift capacity is exceeded; there is a difficult load shape; a lack of safety equipment exists; there is inappropriate use such as lifting people; speeds are too fast for working conditions; or the tractor may not have proper counter balance for the load.
- Falls From Tractors occur when: improperly mounting or dismounting and carrying passengers. DO NOT allow passengers on the tractor.
- Run Over Incidents occur when: others are in the line of travel; extra riders fall from steps, cab or draw bar; there is limited visibility of small children or when backing the tractor toward machinery to be attached; or from by-pass starting.
- Caught-Between Incidents occur when: the tractor is backing up to an implement to hook up.
Tractor Safety:
- Use the tractor responsibly in enclosed spaces to avoid carbon monoxide poisoning. This can occur inside buildings, shops or outdoors in close proximity to the tractor.
- Decontaminate the equipment prior to any repair or maintenance work.
- Use seatbelts when roll over protection is installed and maintain per manufacturer’s instructions.
- Do not use the seatbelt if roll over protection is NOT installed.
- If a Roll Over Protection (ROP) structure is not installed, contact EH&S to determine if one is required.
- Do not use cell phones while operating the tractor.
- Know the terrain such as small holes, depressions, wet areas or stumps that can cause a tip over.
- Keep people and especially small children out of the area where a tractor is operating.
- Follow operator manual instructions especially for side mount implement placement and operating on slopes.
- Use clear communication methods between the operator and ground workers.
- Do not allow ground workers to enter the area between a tractor and its implement until the tractor is stopped, shifted into neutral, brakes applied, and the PTO is not rotating.
- When going up and down the tractor steps, use the handholds, face the tractor, use a 3-point mount, and DO NOT jump off.
- Hitch loads properly to the drawbar.
- Keep the tractor speed low, especially when going downhill on slopes.
- Make wide, slow turns. Set the wheels wide.
- It is better to use a tractor to pull out a tractor from a ditch or muck to avoid injury. Take care in using tire chains, boards, and other traction materials to improve tire traction.
- Fuel the tractor when the engine is off and cool.
- Fire extinguisher and first aid kit should be easily accessible in case of emergency.
Safety Awareness for Power Take Off (PTO) and Moving Part Hazards:
- Do not wear jewelry, loose clothing or allow hair to hang loosely. These can get entangled with the shaft, U-joints, belts, or other rotating/ moving devices and cause serious injury.
- Check for missing or damaged shaft shields prior to hooking up PTO equipment. Do not operate PTO if the shields are damaged or missing.
- Switch off the engine; set engine brake and wait for the tractor and PTO implements to come to a complete stop before dismounting the tractor. Don’t leave a running tractor unattended!
- Stay away from the PTO drive line until all parts have fully ceased rotating. Do not lean over; step across or crawl under the shaft. Do not unplug or adjust any PTOpowered machinery while it is in operation.
- A potential for accidents exists at wrap points; pinch points; shear and cutting points; crush points with hydraulic systems; and by thrown objects. Do not operate if a machine guard is damaged or not in place.
Tractor Operation on the Highway:
- Attach a slow moving vehicle sign. Use headlights, flashing lights, or safety clearance flags.
- Always leave room to stop safely.
- Secure attachments in the transportation position. Do not operate attachments while in transit.
- Keep PTO in neutral.
- Don’t travel on shoulder soft-spots, close to ditches or embankments.
- Drive slow and pull over when needed to let normal traffic pass. Use extra caution when approaching intersections, turns, and curves.
- Independent brakes must be locked together to avoid uneven braking in panic stop situations.
- Watch for blind spots.
- Have a cell phone readily available for emergency phone calls and carry emergency notification contacts.
Personal Protective Equipment:
- Hearing protection for prolonged noise exposure when operating offroad.
- Gloves that fit properly and are the right type for the job. Long pants to protect the skin from flying debris, exhaust burns, and other skin irritants.
- Make sure PPE is chemically resistant if spraying pesticides.
- Respirators to prevent the inhalation of dust, other particulates, and pesticide vapors.
- Eye protection should be impact resistant, provide UV protection, and protect from chemical splash when spraying chemicals.
- Portable eye wash bottles should be on hand when spraying pesticides that require eye protection.
- Foot protection is required to protect feet from injury. Steel toed shoes work best.
Getting Assistance
Contact EH&S if you have any questions about tractor safety.
Heading using the h3tag
Lorem ipsum dolor sit amet, consectetur adipisicing elit, sed do eiusmod tempor incididunt ut labore et dolore magna aliqua. Ut enim ad minim veniam, quis nostrud exercitation ullamco laboris nisi ut aliquip ex ea commodo consequat. Duis aute irure dolor in reprehenderit in voluptate velit esse cillum dolore eu fugiat nulla pariatur. Excepteur sint occaecat cupidatat non proident, sunt in culpa qui officia deserunt mollit anim id est laborum.